Taking care of hiking backpack

I've never had a pack failure 'in the wild' but I think my usual repair kit of duct tape, tie wraps and a bit of paracord should be able to handle most things.

Minor strap and buckle failures aren't likely to cause you major problem - but if a shoulder strap fails, that's quite a challenge: Just remember your pack is a vital part of your gear, and look after it well!

posted over 12 years ago

CC BY-SA 3.0

Roddy‭

126 reputation 1 38 13 0

Buckles, straps and zippers are all relatively easy to replace, but it can be worth taking a spare strap with you in case one fails in the wild.

I usually keep one spare 6 ft strap and a pair of 2 ft bungee cords in the bottom of my camping pack - they also have other uses, so aren't entirely dead weight.

posted over 12 years ago

CC BY-SA 3.0

roryalsop‭

826 reputation 7 248 84 0

Generally speaking, straps and buckles don't just fail one day, you can see signs of wear a while in advance. Of course there are exceptions and you should arguably be prepared for these too, but giving the essentials a glance over once in a while can't do any harm.

As a general pointer, bear in mind your use case as well. If you know your pack is about to endure a tough 5 days that would stretch it even when new, bear in mind that anything even minor that you spot could give way suddenly - so fix and replace when you can rather than taking the risk.

In terms of the time to replace the pack, I'd say it's when multiple things start failing within a short time frame. A strap coming a bit undone once? Fair enough. A strap coming undone, couple of zippers failing and a small hole appearing in a month? Replace it.

posted over 12 years ago

CC BY-SA 3.0

berry120‭

626 reputation 52 134 77 0

Slightly different take here: prevention

You should regularly inspect the pack

1. The joining of straps to seams. Can you see stitching? Can the strap move independently of the seam (even a little)? This is easy to reinforce. I turn it inside out, add a piece of fabric over the inside seam, and stitch just a bit past the original (note this can only really be done once). Alternatively you could use a seam ripper (if the seams aren't taped) and restitch.
2. Straps -- If a strap is worn severely, or torn, you can fix by just stitching a reinforcement strap on top. I use this style of webbing strap. (You can buy strapping material from a fabric store without the buckles.)
3. Zipper -- Are the teeth worn down? Are the stitches showing? If so you may need to replace the zipper, the details of which are a bit beyond this answer.
4. Zipper (part 2) -- Check the "stopper" thing at the bottom. This stops the zipper from zipping open too far and coming apart. If it is too worn or loose, simply stitch ten or so loops of thread around it and they will stop the zipper.
5. Buckles - Your bag probably has plastic buckles. The buckle will be a whitish color, at a spot where it's been bent too far or too much and is starting to fail. If you see that then you need to replace the buckle.
6. Overall -- If you see really worn fabric, a tear, or a hole, even a small one, then you have a major rip waiting to happen. First carefully stitch a stop circle around the hole or tear. Then add a patch of the same fabric as the pack. Do not use iron-on style patches. They create hard edges which will just make things wear faster and create a larger hole. Honestly though, if you're at this point, it's going to be time to replace it soon.

posted over 12 years ago

CC BY-SA 3.0

Russell Steen‭

994 reputation 100 171 129 0